MINIMIZATION OF TOXIC EMISSIONS DURING BURNING LOW-GRADE FUEL AT KAZAKHSTAN THERMAL POWER PLANT

Authors

  • Aliya Askarova al-Farabi Kazakh National University, Faculty of Physics and Technology, al-Farabi Ave, 050040 Almaty, Kazakhstan al-Farabi Kazakh National University, Scientific Research Institute of Experimental and Theoretical Physics, Tole bi 94a, 480012 Almaty, Kazakhstan
  • Pavel Šafařík Czech Technical University in Prague, Faculty of Mechanical Engineering, Department of Fluid Dynamics and Thermodynamics, Technická 4, 166 07 Prague, Czech Republic
  • Aizhan Nugymanova al-Farabi Kazakh National University, Faculty of Physics and Technology, al-Farabi Ave, 050040 Almaty, Kazakhstan
  • Saltanat Bolegenova al-Farabi Kazakh National University, Faculty of Physics and Technology, al-Farabi Ave, 050040 Almaty, Kazakhstan al-Farabi Kazakh National University, Scientific Research Institute of Experimental and Theoretical Physics, Tole bi 94a, 480012 Almaty, Kazakhstan
  • Valeriy Maximov al-Farabi Kazakh National University, Scientific Research Institute of Experimental and Theoretical Physics, Tole bi 94a, 480012 Almaty, Kazakhstan
  • Symbat Bolegenova al-Farabi Kazakh National University, Faculty of Physics and Technology, al-Farabi Ave, 050040 Almaty, Kazakhstan

DOI:

https://doi.org/10.14311/AP.2020.60.0206

Keywords:

Heat and mass transfer, combustion, numerical simulation, stepwise combustion (OFA), aerodynamics, temperature, carbon oxides and nitrogen

Abstract

This paper presents new results of computational experiments on the implementation of Overfire Air (OFA) technologies using an example of a combustion chamber of the BKZ-75 boiler of the Shakhtinskaya power plant (Shakhtinsk, Kazakhstan) burning high-ash Karaganda coal. The effect of mass air flow through special nozzles located above the burner level on the flow aerodynamics, temperature fields, concentration fields of carbon monoxide CO and nitrogen NO over the entire volume of the combustion chamber was studied. The studied characteristics were compared for various percentages of supplying additional air through OFA injectors: OFA is 0% (basic version), 10% and 18 %. It was shown that the installation of OFA injectors leads to a change in the field of the total velocity vector, temperature, and concentrations of carbon oxides and nitrogen. An increase in the percentage of air supplied through OFA injectors to 18% leads to a decrease in the concentrations of carbon monoxide CO by about 36% and nitrogen oxide NO by 25% compared with the base case. The obtained results will optimize the process of burning pulverized fuel in the combustion chamber of the BKZ-75 boiler, increase the efficiency of fuel burnout, reduce harmful emissions and introduce OFAtechnology at other coal-burning thermal power plants.

Downloads

Published

2020-07-01

Issue

Section

Articles