Experimental measurement of heat recovery from shower wastewater
DOI:
https://doi.org/10.14311/AP.2026.66.0413Keywords:
experimental measurement, wastewater, showerAbstract
The wastewater generated during showering represents a potential source of low-grade thermal energy that can be utilised to reduce the energy required for domestic water heating. This paper presents an experimental investigation of a shower wastewater heat recovery system in laboratory conditions. Measurements were carried out during summer and autumn periods under operating modes with and without heat recovery for 6- and 10-minute showering cycles. Temperatures and flow rates of the hot water, cold water, preheated cold water, mixed water, and wastewater were monitored.
The results showed that the temperature of the cold water flowing through the heat exchanger increased by approximately 6–6.5 K. The experimentally determined heat exchanger efficiency reached 38–39 %, while the relative heat savings were approximately 23 %. The measurements also confirmed the effect of real operating conditions, particularly ambient temperature and non-insulated pipelines, on the measured parameters.
Downloads
References
[1] Z. Wehbi, R. Taher, J. Faraj, et al. Waste water heat recovery systems types and applications: Comprehensive review, critical analysis, and potential recommendations. Energy Reports 9:16–33, 2023. https://doi.org/10.1016/j.egyr.2023.05.243
[2] S. S. Cipolla, M. Maglionico. Heat recovery from urban wastewater: Analysis of the variability of flow rate and temperature in the sewer of Bologna, Italy. Energy Procedia 45:288–297, 2014. https://doi.org/10.1016/j.egypro.2014.01.031
[3] X. Jin, K. Baker, D. Christensen, S. Isley. Foresee: A user-centric home energy management system for energy efficiency and demand response. Applied Energy 205:1583–1595, 2017. https://doi.org/10.1016/j.apenergy.2017.08.166
[4] Q. Zhang, X. Zhao, H. Lu, et al. Waste energy recovery and energy efficiency improvement in China’s iron and steel industry. Applied Energy 191:502–520, 2017. https://doi.org/10.1016/j.apenergy.2017.01.072
[5] L. Ni, S. Lau, H. Li, et al. Feasibility study of a localized residential grey water energy-recovery system. Applied Thermal Engineering 39:53–62, 2012. https://doi.org/10.1016/j.applthermaleng.2012.01.031
[6] J.-B. Bouvenot, C. Beaudet. In situ experimental and theoretical studies of the performance and the fouling impact of shower greywater heat recovery systems. Energy and Buildings 331:115341, 2025. https://doi.org/10.1016/j.enbuild.2025.115341
[7] T. Matuška, R. Vavřička. Úspora tepla dosažená rekuperačním výměníkem v reálném provozu [In Czech; Heat savings achieved by a recovery heat exchanger in real operation], 2016. [2026-02-03]. https://voda.tzb-info.cz/priprava-teplevody/15057-uspora-tepla-dosazena-rekuperacnimvymenikem-v-realnem-provozu
[8] R. Vavřička, J. Boháč, T. Matuška. Experimental development of the plate shower heat exchanger to reduce the domestic hot water energy demand. Energy and Buildings 254:111536, 2022. https://doi.org/10.1016/j.enbuild.2021.111536
[9] Úrad pre normalizáciu, metrológiu a skúšobníctvo Slovenskej republiky. STN EN 1717. Ochrana pitnej vody pred znečistením vo vnútornom vodovode a všeobecné požiadavky na zabezpečovacie zariadenia na zamedzenie znečistenia pri spätnom prúdení [In Slovak; Protection against pollution of potable water in water installations and general requirements of devices to prevent pollution by backflow], 2025.
[10] P. Sevela, J. Frenger, J. Schnieders, R. Pfluger. Potential of waste water heat recovery in reducing the EU’s energy need. CLIMA 2022 conference 2022. https://doi.org/10.34641/clima.2022.439
[11] Zypho. Zypho products. [2026-02-03]. https://zypho.uk/zypho-products/
[12] K. Ferstl, M. Masaryk. Prenos tepla [In Slovak; Heat transfer]. Slovenská technická univerzita v Bratislave, Bratislava, Slovakia, 2011. ISBN 978-80-227-3534-6.
[13] L. Hrnčárová, J. Peráčková. Vplyv rekuperácie odpadového tepla z kanalizácie na energetický certifikát objektu [In Slovak; The effect of sewage waste heat recovery on a building’s energy certificate]. Vytápění, větrání, instalace 34(3):108–112, 2025.
[14] R. Vavřička, T. Matuška. Zpětné získávání tepla v oblasti přípravy teplé vody [In Czech; Heat recovery in domestic hot water preparation], 2016. [2026-02-03]. https://voda.tzb-info.cz/priprava-teplevody/14974-zpetne-ziskavani-tepla-v-oblastipripravy-teple-vody
Downloads
Published
Issue
Section
License
Copyright (c) 2026 Lucia Hrnčárová, Jana Peráčková
This work is licensed under a Creative Commons Attribution 4.0 International License.
